Driveways, parking lots and private roads paved in hot-mix asphalt for Arcadia Valley homes and businesses, built on compacted rock.
Free estimates25% off
Main routes: Highway 21 and Highway 221
The mountain this town is named for once worked as a landmark, a pilot for hunters and travelers finding their way through these hills. Paving in the Arcadia Valley still comes down to reading ground: where rock sits close to the surface, where the grade runs, and where water goes after a hard rain.
We pave home driveways and parking lots here, plus the private roads and access drives that serve them. Highway 21 runs through town and Highway 221 begins nearby, so lots along those routes take through traffic. Rhyolite from the St. Francois Mountains is used as road aggregate and construction stone, which fits: good rock, properly compacted, is most of what makes asphalt last. Free estimates, and you get 25% off.
Valley lots and hillside lots both show up here. On a hillside drive we set a cross slope so runoff leaves at the side instead of scouring the length of it, and we support the low edge. On flatter valley ground the job is drainage away from the house and a base deep enough to stay firm. Home drives typically finish at 2 to 3 inches of compacted hot mix.
Driveway pavingLots at shops, churches and the visitor traffic around the Fort Davidson historic site take a mix of cars, buses and delivery trucks. We size the base for the heaviest of those, slope the pavement toward planned outlets, and keep entrances clear where they meet Highway 21. A sound older lot may suit an overlay rather than a full rebuild.
Parking lot pavingPrivate roads and access drives here climb and turn, which loads the outside edge and whatever is supposed to carry water across the road. We grade and crown, set culverts, compact rock in lifts and pave to the thickness the traffic calls for. Chip seal and recycled asphalt millings suit the longer rural lanes.
Road constructionIn a town like Pilot Knob, general asphalt work covers a lot of ground: shop and church lots, alley aprons, repairs along a curb line, overlays on older streets and pads for equipment. The approach stays the same: fix the base, lay the hot mix, roll it tight, finish the edges.
Asphalt paving
The knobs of the St. Francois Mountains are hard rhyolite, and the ground around them runs from rock near the surface to pockets of soft soil down in the valley. A base that works in one spot may not work forty feet away. We check the subgrade as we go, then compact rock in layers so freeze-thaw winters have less to work on.
Bids are only comparable when they spell out the same things: base depth, compacted thickness, how edges are finished, and where water is meant to go. Ask for those before you pick a number.
Typical ranges. Your Pilot Knob estimate is sized to the soil, the traffic and the drainage on your property.
Straight answers for Pilot Knob homeowners and property managers. Anything else, call (866) 490-7680.
It happens in this valley. Shallow rock is often good news, since it gives a firm foundation, but it can force a change in grade or limit how deep we cut. We look at what is likely before quoting and tell you how we would handle it.
Yes. Pilot Knob, Ironton and Arcadia sit close together in the Arcadia Valley, and we work across all three plus the surrounding Iron County roads. One trip out can cover neighbors who want work done at the same time. Estimates are free, with 25% off.
Hot-mix asphalt needs warm air and warm ground to compact properly, and the plants serving Pilot Knob typically run from spring into late fall. Winter is a good time to get your estimate and book a spot for the season.
Only if the grade changes. Paving over a low spot in Pilot Knob leaves the same low spot in a smoother surface. We measure the fall first and tell you what it takes to move the water.
We pave all around Pilot Knob, across Iron County and the rest of greater St. Louis on both sides of the river.
| Town | County | Miles from Pilot Knob |
|---|---|---|
| Iron Mountain Lake, MO | St. Francois County | 4.9 |
| Bismarck, MO | St. Francois County | 10.1 |
| Doe Run, MO | St. Francois County | 11.6 |
| Caledonia, MO | Washington County | 12.0 |
| Irondale, MO | Washington County | 14.9 |
| Wortham, MO | St. Francois County | 15.2 |
| Park Hills, MO | St. Francois County | 15.6 |
| Knob Lick, MO | St. Francois County | 15.6 |
| Farmington, MO | St. Francois County | 16.2 |
| Frankclay, MO | St. Francois County | 16.7 |
Free on-site estimates and 25% off. Driveways, parking lots and private roads in Pilot Knob and the towns around it.
Tell us what you want paved and where. We'll call to set up a time to walk the site, measure, and give you a written quote with your 25% off.